ember cooked vegetables can be done in a cask iron plan, fire box and even in a Hibachi! Try this unique cooking method to add a flare and unique tastes to your outdoor grilling and cooking!

TOP 10 EMBER COOKED VEGETABLES

listen to our blog regarding wood chips for smoking

I want to be perfectly clear – this is not cooking over hot flame or direct flame. This is cooking after the wood and/or charcoal has burned down in to very hot coals; when the coals develop a white-gray ash coating. THIS is the time for coal or hot ember cooked vegetables.

The Rules of Hot Ember and Ash Cooking

The essence of using all that the wood can give for cooking. That it was ember or coal cooking is. I want to be sure there is no misunderstanding on what is needed to do this type of cooking safely and effectively.

Rule #1: If going with all wood for the coals, only use hardwood and clean hardwood at that. You’re going to lay foods into this material so I believe it should be clean and mold free with moisture level 15-20%. If higher, it will simply take longer to get to the coal stage.

Rule #2: Again, if using all hardwood, try to limit the bark or go bark-free if possible to reduce the potential for mold spores that can be released into the air.

Rule #3: Have everything ready before you start. You’ll need an ash-coal hoe, fire gloves, and small coal shovel at the ready. I would also have tongs for those times when you don’t bury your foods completely in the coals but rather lay them which requires turning of the vegetables.

Rule #4: Equipment wise, you can use a charcoal grill that has fire brick added for insulation, a clean fireplace (I prefer an outdoor unit), a clean fire pit, or an open pit built in a safe area with brick or gravel as the base to protect the fire from spreading.

Ember Cooked Vegetables- Hot Embers Birthed in One Hour

On average, it will take about an hour to move a small fire from flame to hot ember. Depending on whether you elect to use charcoal or wood will determine the amount of time the fire needs to burn down – an all charcoal fire will be 30-45 minutes; all hardwood fire about 45-60 minutes. Remember, charcoal produces heat and little smoke, whereas hardwood, produces heat, smoke and specific aromatics and flavorings in that smoke. At the hot ember-coal level, both have equal carbonization and act similar for this method of cooking.

Using approximately 8 lbs. of charcoal or 10 lbs. of hardwood, or any combination of the two, light a fire in the equipment of your choice. Let the fire completely burn down until only hot coals remain. Rake the coals to produce a thick even bed. Then select your favorite vegetables from the ones listed below, and you’re on your way! Always keep a small fire going for additional hot coals if doing large amounts of vegetables.

Ember Cooked Vegetables- They Love Hot Coals

Here are the top 10 vegetables to hot ember cook for fantastic flavor:

Asparagus Broccoli Cauliflower Eggplant

Garlic Leeks Gourds (squash, pumpkin)

Onion Peppers Potato

If you want minimal monitoring to the actual cooking process, then place the selected vegetables into the bed of coals and then shovel hot coals and ash over the top so that the entire vegetable surface is covered in embers. Leave untouched until tenderized, which will be 45-60 minutes depending on the vegetable selected. Otherwise, you can set vegetables within the coal bed and turn them during the cooking process to ensure even char.

The Culinary Team wants you to know …

… that cooking food with wood, whether it be directly on embers or more of the traditional way- above the heat source on grates, needn’t be an all meat, all protein cooking episode. As our blog explains many vegetables can and should be the “main event” for your wood-fired cooking events. Dense or thick-skinned fruits are great too! So, be it veggies or fruits, ember cooked or grilled conventionally, your taste buds will be treated to rich, unparalleled flavors. Give ‘em a try!

Leave a comment or suggestion as we’d love to hear from you so we can bring the information you’re looking for. And don’t forget, follow us and subscribe so you don’t miss a thing!­­

For related reading:

More Related reading on “What Wood for Smoking” and other great smoking and grilling tips and techniques

-THAT EMBER GLOW!

-EMBER FIRED ASPARAGUS ON THE HIBACHI

-EMBER COOKED SWEET PEPPERS

-EMBER COOKING/ROASTING GARLIC IN AN IRON SKILLET

SmokinLicious products in this blog:

Wood Chips- Grande Sapore®

Dr Smoke- “Try ember cooking; it is a great way to entertain your guests and enhance your grilling skills.”

When you ask why people grill we found the answer very interesting!

You may not be aware that every year a trade show is held usually in the month of March that is dedicated to all things related to fireplace, stove, heater, barbecue, and outdoor living appliances and accessories. In addition to the trade show, this organization, known as HPBA or Hearth, Patio & Barbecue Association, conducts various surveys every couple of years. A recent survey was posted asking the question “Why do people grill?”

The top answer to this survey surprised and THRILLED me!

Why People Grill? – Most Recent Statistics

For North America, owning a grill is common. Currently, in the United States, 7 of 10 adults own a grill while in Canada that number increases to 8 of 10. Gas grills remain the most popular (64%) with charcoal units coming in second (44%). When looking at the most popular times of the year to use the grill, holidays, of course, dominate. Memorial Day and 4^th of July are the clear winners for firing up the grill but Father’s Day remains a high demand grilling day as well likely due to this holiday falling right before true summer begins on the North American calendar. Of course, Labor Day is not far behind on the list.

This survey will be conducted again in 2019 with updated numbers likely available by the close of the year. I can’t wait to view them to see current trends.

Now to the question of “Why do people grill?”

Why People Grill? – It’s All About Flavor

The number one reason people stated for grilling is for flavor! This got me thinking about this answer.

What exactly made the flavor difference? Is it that the heat of the grill produced changes in the ingredients used? Was it the charring affect from direct fire of the grill which leads to a distinct taste? Or was it the flavor choices used when grilling with wood like wood chips, wood chunks, and charcoal?

I think without adding these follow up questions, it’s very hard to know just what the flavor enhancer is when grilling for these respondents.

For me, there is no question that it is the introduction of smoke to my outdoor cooking experience. Whether I’m cooking on a gas grill that I’ve included a smoker box of wood chunks, a charcoal grill equipped with hardwood charcoal or charwood plus wood chunks, an electric grill I’ve incorporate a micro wood chip product, or my outdoor fireplace that I’ve converted to an open pit fire using hardwood, I let the tantalizing smoke vapor work with the other ingredients of my foods to bring out the best of all the blended flavors.

Direct fire or indirect cooking, either way the eating experience of foods cooked grilled, smoked, or by embers is unique and is likely the reason why people from around the world continue to seek out these methods of cooking.

So I agree with the 72% of North Americans who say they grill for flavor but I’d certainly add that I grill for flavor that is heightened by the addition of the natural plant material known as hardwood which takes my grilling to an umami level that’s hard to beat by any other cooking method.

What is your reason for grilling? Let us know in the comments and don’t forget to follow us on all platforms. Providing tips, techniques, recipes, and the science behind the flame and fire to improve your skills with wood-fired cooking! That’s SmokinLicious®!

SmokinLicious products in this blog:

Charwood

Wood Chunks- Double & Single Filet

Wood Chips- Grande Sapore®, Minuto®, & Piccolo®

More blogs you might enjoy:

–BOOST UP THE FLAVOR OF YOUR SMOKER BOX!

–GRILLING & SMOKING QUESTIONS/ANSWERS THAT MAY SURPRISE YOU!

–TEMPERATURE, MATERIAL AND TIME DETERMINE WHEN ITS CALLED BARBECUE

Enjoyed this blog? Please spread the word

Our double filet box of pristine, NO BARK, hardwood wood chunk for smoking ready for the next customer!

WHAT’S IN THE SMOKINLICIOUS® WOOD CHUNK FOR SMOKING BOX? Share on X

These two questions have been quite common for the 12+ years we’ve been in business. What does a cubic foot box of wood weigh? How many pieces do you estimate are in a cubic foot box of wood?

Due to the regulations imposed by The National Conference on Weights and Measures -Uniform Regulation for the Method of Sale of Commodities, we cannot specify weight on a wood product, even though we are a cooking wood. Instead, when asked about weight, we only provide an estimate clearly stating that wood is not sold by weight due to the variation in moisture level and density of the wood selected.

I can, however, tell you the details that a recent first-time customer posted to an online forum that had me elated!

The Specifics You’ve Asked About Wood Chunk for Smoking

This customer took a lot of time and effort to get to the details about our wood; the packaging and the weight not just of the carton, but of specific select pieces. This customer purchased the Serious Smoker Double Filet Wood Chunk which is our cubic foot carton product with the smallest chunk sizing. We offer an option to select up to 3 wood choices for this carton size, with this customer selecting our 3 most popular hardwoods: Hickory, Sugar Maple, and Wild Cherry.

First, let’s look at this customer’s overall purchase.

Wood Chunk for Smoking- It’s In The Numbers

The packaged hardwood weighed in a 32.5 lbs. A total of 139 pieces of wood were packaged. Of that total, 48 pieces were Wild Cherry, 44 pieces Sugar Maple, and 47 pieces Hickory.

Individual Weights

This customer owns equipment that references specific weight of wood needed to smoke optimally. In this case, just 2-4 ounces of wood is ideal.

Although weights for each of the 139 pieces of wood were not obtained, sufficient sampling was done. Here is what was reported:

• the lowest weight of a Wild Cherry chunk (remember, these are all double filet) was 1.5 ounces and the highest was 4.1 ounces
• lowest weight of a Sugar Maple chunk was 2 ounces and the highest at 5.7 ounces
• lowest weight of a Hickory chunk was 2.8 ounces and the highest at 6.4 ounces

For this equipment user, there was an estimate that 139 pieces of hardwood would provide for some 100 smoking events!

What I loved the most about this report is that it correlates specifically to the density of these 3 hardwoods. Hickory has the highest density of the 3 kinds of wood selected and this is reflected by the weight of the individual pieces sampled. Sugar Maple would be next in density followed by the Wild Cherry, all proven with the reported weights.

What Did You Learn?

Unquestionably, there is a lot of wood chunk pieces in a cubic foot carton! Which means you want to ensure you can use that much wood in a reasonable amount of time to maximize the freshness factor and peak level for function as a smoking wood. Individual pieces will vary in weight even if the dimensions of the pieces are relatively the same. That is the nature of a water-rich material – the water weight influences the overall piece weight.

We are indebted to this customer for taking the time to inform us all of his findings since, by law, SmokinLicious® can’t offer this detail.

We hope you liked this post. We’d love to hear from you so subscribe, comment and follow us on all social media platforms. Keep those suggestions coming for the future information you crave.

More Related reading on “What Wood for Smoking” and other great smoking and grilling tips and techniques

Additional reading:

–HOW MUCH WOOD TO ADD WHEN SMOKING

–BOOST UP THE FLAVOR OF YOUR SMOKER BOX!

–THE ART OF CUSTOMIZING YOUR COOKING EXPERIENCE

Our Products Discussed in this Blog:

Wood Chunks- Double Filet

Dr. Smoke- “Thank you to this great customer for analyzing our box- wood chunk for smoking.”

Great beech wood for smoking results are provided from many beech species

Not the most popular of hardwoods in the North American region and certainly it doesn’t have the following in the European market. However, this is still an interesting hardwood to use for wood-fired cooking techniques.

Going Beech! That means your entering the wood family that includes white oak as a relative. Part of the Fagaceae family, the variety we manufacture is Fagus grandifolia Ehrh. Unlike its cousin, Beech doesn’t produce a heavy, pungent flavouring but rather a more balanced, medium toned profile. The common names for the varieties found in the Western New York and Northwestern Pennsylvania regions are American Beech and Red Beech.

Less temperament than Oak, Beech is considered a rather bland wood to look at. When it is exposed to steam/heat, it takes on a golden hue and that is commonly what the coloring to various meats, poultry, and fish will also show. Keep in mind, like all of our cooking woods, the descriptors used are truly in the palate of the taster. There are no rules that say one wood must be used with a specific food. Experimentation is what the art of fire cooking is all about. And, the region that the wood is harvested from also factors into the flavoring it will provide when foods are exposed to it. The same wood in a western state will not produce the same flavoring as the wood from an eastern state. Everything interacts with the tree: soil pH, growth location, sun exposure, precipitation exposure, etc.

Heat Level: High – 21.8 MBTU

Fuel Efficiency: Excellent

Ease of Lighting: Poor

Ideal Uses: Baking/Grilling/Roasting/Braising/Pit Roasting/Hot Smoking/Cold Smoking

So, take a go at Beech, even if it takes a bit to get it lite. The aroma is pleasant, the burn time is extensive, and the infusion appealing.

The Culinary Team wants you to know …

… although Beech is common in many areas of the world and often used to smoke foods and brew beer in the European tradition, our harvest region of the Eastern Appalachian Mountains has a distinctive balance of soil Ph levels and climate conditions which give our Beech hardwood cooking products a ‘one of a kind’ smoky flavor profile that can be used for a wide variety of foods!

Smokinlicious® products used in this Blog:

Wood Chunks- Double Filet

Wood Chips- Grande Sapore®

More Related reading on cooking and smoking woods like beech wood for smoking:

-BEECH IS CERTAINLY “GRAND” IN EUROPEAN SMOKER WOODS

-WHAT WOOD TO USE FOR SMOKING: A PRIMER

-THE PRECIOUS FOREST

Dr. Smoke- Dr. Smoke- “Often a favorite of many chefs, beech wood for smoking offers a touch of European mellow flavor!”

Wines to pair with your smoked Meat is important but not easy!

Great Sustainable Wines To Pair With Your Smoked Meat Guest blog by — Kylee Harris is an events planner and writer who is a strong advocate of allergy awareness.

listen to our blog regarding wood chips for smoking

She has also expanded her mission to stress the importance of food safety not just in events, but in her community. She also has a great eye for current interests and finds great ways to tie wood fired foods and sustainable food practices together.

Back in 2015, only 6% of consumers said that their first choice of wine would be a bottle that is produced in a sustainable way. This figure has been steadily rising. The 2018 American Wine Consumers Survey even showed that customers are willing to pay $3 more for a sustainable option. They want an environmentally-conscious wine that has been made from ethically grown grape varieties. The farming process is pesticide free and even bottling the wine is done in a way that won’t cause harm to the environment. It has even been suggested (although not proved as yet) that sustainable, organic wine can prevent a hangover. You’re more than welcome to test out this theory – and even better, you can pair the wine with some delicious smoked meat.

Wines to Pair- Maple-Smoked Pork Chops

Pairing your wine with smoked meat, is all about complimenting the delicate smoky flavor of the wood used. Maple-smoked meat will naturally have a slightly sweet and fragrant taste. This can be achieved by using maple woodchips in your barbecue or smoker. In order to contrast the sweet maple taste and the white umami flavor of pork, you should pair your meal with a sharp and zingy white wine. Benziger Family Winery

in Sonoma county have a few delicious and fresh Chardonnay options, including the Coelo Chardonnay and the West Rows Chardonnay. Perfect for a barbecue on a hot summer’s day with friends and family. Don’t forget you can also buy sustainable wines by the can – this makes it so easy to keep cool when you’re having a garden party. Everyone can help themselves.

Wines to Pair- White Oak Smoked Venison

The strong and almost pungent aromas of white oak are best paired with a dark, gamey meat that can hold its own. Duck breast, pigeon and venison are good choices. The white oak adds a complimentary bitterness that balances well with the rich flavors. A hearty sustainable red wine is a good option with smoked white oak. Silver Oak Vineyard in Napa Valley have a fruity and dark Cabernet Sauvignon that pairs beautifully with White Oak smoked dark meat. New York’s sustainable Red Tail Ridge Winery offer a tangy Teroldego,

which is similar to Syrah that is a great partner to White Oak smoked venison.

Wines to Pair- Alder-Smoked Seabass

The mild flavor profile of alder makes it the perfect wood choice to smoke fish with – particularly slightly salty seabass. The taste of the alder itself adds a slightly sweet taste to the fish, even if it is only smoked for a short amount of time. Pairing alder with a sustainable wine is easy. A good Prosecco or sparkling wine will work well – look for something dry and fresh. Left Coast Cellars in Oregon have a lively Blanc de Noir

that is perfect with alder. It adds citrus notes of lemon and pineapple, which complement the taste of the smoke and the fish well.

There are an increasing number of vineyards and suppliers in America offering truly sustainable wine. Pair something tasty and delicious with your smoked meat and enjoy a great meal.

More blogs you may enjoy:

–Sip ‘Em If You Got ‘Em: Smoked Whiskey Cocktails And Meat

-HOW TO MAKE THE BEST SMOKY COCKTAILS

–How To Maintain A Safe Kitchen Environment

[Fruitwood trees are often sprayed with pesticide to maximize the fruit yield. Spraying of chemical on the bark may not be too good for using in barbecue?]

ARE FRUITWOOD TREES LIKE THE APPLE “SNOW WHITE” BIT INTO?

There is a fierce debate out there about the use of fruitwood trees, specifically apple and cherry varieties, for cooking purposes. As a Company, we frequently get the same question – “Why don’t I see Applewood as an option to purchase?” Here’s the short answer: We do not, and will not, produce our products from orchard-based woods. Our reason is simple – we do not believe in smoking foods over woods that have been or have the potential to be sprayed or growth enhanced with chemicals.

Trees

Let’s review a fact about trees. All trees produce prussic acid, better known as hydrogen cyanide. We feel that humans can use woods produced in nature when they have been left alone, unburdened by the human hand in trying to manage what sometimes is the normal cyclical pattern of nature. In the areas in which we purchase the heartwood for our cooking wood production facility, the varieties of cherry (Prunus pensylvanica L.f.) we commonly deal with are:

• Northern Pin Cherry, Fire Cherry,
• Wild Red Cherry, and Pigeon Cherry.

Of course, predominately, we bring in Wild Red Cherry. There are many different cherry tree varieties available throughout North America. The main difference in these woods is that our forest trees, the type we manufacture, tend to be on the sweet-tart side versus the sour-bitter. For the most part, hydrogen cyanide is found mainly in the leaves and seeds of the cherry tree. Black Cherry bark is also commonly used in herbal cough remedies.

Opinion:

The dominant opinion is that when used in small quantities, the hydrogen cyanide is a moot issue. Now let’s talk about the smoking application of wood. Cyanogenic compounds WOULD remain a factor in our production of cooking wood. This is because we do not allow our woods to deplete their moisture content to a level that other wood product manufacturers may (what is commonly referred to as “seasoning of the wood”).

For ideal smoking of foods, wood needs to have a moisture level preferably at ~20%. This results in the wood smoldering rather than burning at a rapid rate. The resulting smoke from the plant material provides for that wonderful flavor. Because smoking is done at low temperatures for longer periods of time, the polycyclic aromatic hydrocarbons (PAH’s) found in wood molecules are not stimulated as they normally would be when cooking, say, a steak over a hot flame. Thus, the health risk associated with PAH’s and smoked foods is not considered an issue. The same can be said for ember cooking – using the heat of the residual coals to cook foods.

OUR CONCERN:

Our main concerns regarding woods used for wood-fired cooking methods is to always ensure a bark-free product. Bark does not hold moisture but rather is designed to rid the tree of wastes by absorbing them and locking them into this area. In fact, this is the reason why bark-on woods burn so much faster than bark-free wood pieces. This portion of the tree is responsible for temperature flare-ups, tainted smells, ‘spotty’ appearance of the food’s skin, creosote, an increase in the production of ash. Additionally, once the temperature is increased during wood-fired cooking, heterocyclic amines, or HCAs, are created due to the reaction of the amino acids and creatine with the higher cooking temperature.

In a nutshell, a person is at greater risk of cyanide exposure in treated wood products for home construction than they are when consuming BBQ or other wood-fired foods. Knowing the source of the wood being used in the cooking application is vital to ensure that the necessary steps have been taken to prevent tree disease and pest infestation spread, as well as to ensure that the wood has not been exposed to any chemical/toxin treatments.

It is our hope, that one day soon, inspection of the wood products used by restaurants, caterers, BBQ competitors, and grocery stores who promote smoked and natural-wood fired foods, will occur as normally as food inspections. After all, I think we all can agree that WHAT you cook the food over is just as important as what food you are cooking!

ARE FRUITWOOD TREES LIKE THE APPLE “SNOW WHITE” BIT INTO? Share on X

More Related reading on “What Wood for Smoking” and other great smoking and grilling tips and techniques

For related reading:

TO BARK OR NOT

TASTE IS AROMA!

WOOD FIRED CLAMS MAKE THIS THE PERFECT BITE

Purchase products:

Wood Chunks- Double & Single Filet
Wood Chips- Grande Sapore®

Dr. Smoke- “Enjoy the fruit of the tree because that is what they’re there for. Just be careful when using fruitwood trees from orchard based woods to cook your food.”

Grilling our Smoked Beef Shanks on the Gas grill with Double filet wood chunks in our smoker box!

OVER THE TOP GRILLED & SMOKED BEEF SHANKS

I’m going to make a confession. I rarely select steak to grill anymore. The reason – there are just too many other options that I simply prefer. Like beef riblets, short ribs, and shank. Oh, the bone-in shank! That is my favorite.

I’m going to give you a wet rub recipe and a grilling technique you can do on the grill of your choice, though I’ll be picking the easy gas grill. Get to the butcher and select some premium bone-in beef shanks then visit SmokinLicious® online for some wood chunks. Then get ready for the best grilled & smoked beef shanks you’ve ever had!

Smoked Beef Shanks- A Great Wet Rub

I tend to lean toward some Asian-inspired ingredients for my rubs, especially those that are a wet rub. While working on the rub, be sure you’ve started your grill so it will be ready to go when the meat is rubbed. Remember, we are using a two-zone set up for the grill so burners lit only on one side of the gas grill with the wood chunks placed on the heat shield or in a smoker box placed over the lit burners like I’ve done. Or, for the charcoal/wood grill, hot coals banked to one side of the grill.

For this wet rub, you’ll need equal parts of the following ingredients:

• Ground ginger
• Whole allspice – about 30
• Garlic powder
• Cinnamon
• Cocoa powder
• Sesame oil
• Worcestershire sauce
• Hoisin sauce
• Honey

Start by combining the dry ingredients, followed by the wet and combine with mortar and pestle until a paste is made. Then coat the beef shanks on both sides and the edges with the wet rub. I line a disposable foil pan with a roasting rack, then place the shanks on the rack.

Tasting Notes: don’t be afraid to use a store-bought rub and simply add oil and/or garlic/spice pastes. There is nothing off limits when it comes to producing a rub.

Smoking

Time to open the pre-heated grill and start the cooking of the shanks. The wood chunks should be smoking well at this point so add the shank pan to the unlit side of the grill. Leave untouched for at least 40 minutes. Return to check the internal temperature. Flip the shanks and rotate the foil pan. Leave until the meat registers 140-145° F.

Tasting Notes: select the hardwood you like or use a combination of hardwoods like I did with my shanks – maple, hickory and white oak.

Smoked Beef Shanks- Serve ’em Up

When done, I simply slice against the grain for beautiful, flavorful beef that has a controlled infusion of smoke. Here’s a tip: be sure you enjoy the marrow in the bones! It is very rich so if you elect not to eat it when the meat is done, use it with onions and shallots to make a confit, or use it with a rich pasta dish to make the flavor of the richness even more stunning. Or, combine the marrow with an acidic dish like an arugula salad with lemon and capers. And don’t forget to save the bones to make our smoked beef broth. Two zone cooking makes it so easy to control the smoke infusion and produce perfection in any item grilled.

What’s your favorite beef cut to grill and smoke? Bringing innovation to wood-fired cooking with recipes, techniques and the science behind the fire, smoke, and flavor. That’s SmokinLicious®.

finished beef shanks sliced

Purchase products:

Wood Chunks- Double and Single Filet

More Related reading on “What Wood for Smoking” and other great smoking and grilling tips and techniques

Additional reading:

-SMOKED BEEF SHORT RIBS

-WHY IS MY BARBECUE MEAT DRY??

-GIVE ME THAT BEEF BRISKET!

DR smoke OVER THE TOP GRILLED & SMOKED BEEF SHANKS ON THE GAS GRILL

Smoker Box for gas grill Available at Retail Locations

BOOST UP THE FLAVOR OF YOUR SMOKER BOX! Share on X

BOOST UP THE FLAVOR OF YOUR SMOKER BOX!- People are always in search of that great flavor to food that only comes from hardwood. In fact, it is common for discussions around outdoor cooking to use the terms grilling and barbecuing interchangeably as if they mean exactly the same thing. Let’s be clear – cooking with just LP/Gas is grilling. Barbecue is outdoor cooking over hot coals or wood, whether in lump charcoal form or straight hardwood pieces.

Barbecue vs. Grilling

In an effort for grilling equipment manufacturers to compete with charcoal grills and smokers, many began integrating a wood chip drawer in their units to imply that “barbecue” was possible on a gas grill. If you ever tried these, you likely were disappointed in finding that the intensity of flavor just didn’t compare to charcoal equipment. Then the smoker box was developed with a wide variety of design options from rectangular in shape, V-shaped at the base to fit between grill grates, and venting hole configurations that made claim to more intense smoke penetration. Here’s the thing – no one ever discussed what should go in the smoker box. The assumption was to always use wood chips but I am going to take you on a flavor journey using that box that will open your eyes to understanding cooking with hardwood.

One of the key complaints I hear is that when using wood chips in a smoking box or drawer, the chips don’t seem to give off enough smoke and have a very short burn life. In fact, refilling the box or drawer is often needed to finish a simple food item like chicken pieces or ½ slabs of pork ribs. Wood chunks or uniformed sized pieces of hardwood lend to a much longer burn/smolder rate and give off great flavor infusion.

(more…)

Chef Calle’s finesse technique of Grilling & Smoking Shallots on the charcoal grill using Charwood for the smoky wood flavor

Grilling & Smoking Shallots with a Finesse Technique

By: Chef Calle, Resident Executive Chef

For all my BBQ cooking friends who have been under the assumption that grilling is only for protein food groups, (beef, pork, fish etc.) boy do I have a taste revelation that could transform you into a disciple of the vegetable sections at local farmers markets– Char Grilled and Smoked Shallots!

Process for Grilling & Smoking Shallots

The process is fairly straightforward but doesn’t get the impression that this food item is something that you can flop on the grill grate and walk away from for an extended period of time. Finesse is the cooking standard that must be applied to enjoy the maximum flavor result rendered from this sweet cousin of the onion family.

You can tell by my strong friendship with the folks at SmokinLicious®, that I’m a big advocate of grilling with a hardwood fire. It allows for uniform cooking temperatures while simultaneously infuses food items with a natural wood smoke flavor.

So, as we begin, go about preparing your grill with only the best hardwood cooking wood and remember- never, ever start your fire with a chemically based liquid starting fluid. Use a chimney starter!

While your grill preheats to a medium temperature, prepare the whole shallots by cutting off the tips and drizzling them with skins on using the high-quality EVOO and a touch of Kosher salt. You can even season with fresh thyme or sage and let marinate for a few minutes.

Grilling & Smoking Shallots- Technique

Grilled shallots are a great side dish or garnish to prepare alongside your protein or immediately after you have removed your meat to let it rest.

Place the shallots on the grate directly over the outer fringes of the embers, ideally between the smoking wood chips and outer ring of embers. Do not place them directly over the center most concentration of the embers. If you want a slightly stronger smoky flavor, cover. If not, leave uncovered.

Here’s where the finesse part comes in- over the next 3-10 minutes, (depending on the heat and size of the shallots) watch over the shallots like a hawk watches over hatchlings in a nest. Turn often, get a good char on all sides but, for Heaven’s sake – don’t allow them to ignite into a raging conflagration! If this happens, you will lose much of the smoky sweetness and be left with a bitter tasting, burnt onion. You can best determine a great finish when the outer skins are charred nicely while the centers have a soft, moist feel when gently squeezed with cooking tongs or fingers.

Remove from the grill, let them cool a bit. Once cooled for 2-5 minutes lightly squeeze the charred outer skin and out will come the sweet and delicious interior.

After you experience the fabulous smoky flavor of your grilled shallots, I’m sure you’ll have a greater appreciation for all the food flavor benefits that can be had from your backyard grill!

Purchase Products:

Wood Chips- Grande Sapore®

More Related reading on “What Wood for Smoking” and other great smoking and grilling tips and techniques

Related reading:

-Charwood Grilled Salmon Fillets for a Hint of Smoky Flavor

-TOP 10 VEGETABLES TO HOT EMBER COOK

-Roasted/Toasted Onions over Embers

http://www.foodnetwork.com

Dr. Thank you Chef Calle for your finesse technique for Grilling & Smoking Shallots on the charcoal grill

Charcoal that is produce properly is a fuel and provides heat! Wood adds flavor!

WHY CHARCOAL IS NOT AN INGREDIENT

There are so many methods of getting a message out rapidly given the speed of technology and the many platforms for posting opinions and marketing strategies today. In doing research for a publication, I came across a statement made by a charcoal company that made me a bit … confused.

An Ingredient Not A Fuel

This company claimed that their product was an ingredient, not a fuel!

Not a fuel? That statement is in direct conflict to what charcoal manufacture was designed for – heat.

I realize that when used with 100% accuracy, charcoal will produce no smoke and a consistent heat. We all know that the 100% accuracy is the kicker – pretty much no one is proficient at producing full ignition of the charcoal with stable air intake to maintain the high heat level the product was designed for. What usually occurs is that we start out with full ignition but given the need for longer cooks, we add charcoal and thus, start to fluctuate the oxygen feed. Only during those fluctuations does the production of smoke occur with charcoal.

Non-Carbonized Wood IS Flavor

Charcoal production is the act of carbonizing wood which means all the volatiles of the wood is burned off until what is left is pure carbon or at least a high percentage of carbon. There is no refuting that it burns cleaner, hotter, and more evenly than wood only.

Here are where differences occur though when it comes to types of charcoal.

Lump charcoal is made from various scrap wood sources like furniture manufacture, a wood packaging manufacturer, the flooring manufacturer, and building material scraps. Due to the high level of variation in these pieces, most often there is not 100% carbonization of the lump charcoal production. That’s why you can get some smoke and flavor from that product; when combustion of a non-charred piece occurs, you’ll stimulate organic compounds that produce flavor. Keep in mind, because scrap wood is used you can get other debris in the purchased bag as often this is scooped up from a site and transferred to a production facility, with the scoop gathering anything that may be in the area.

Traditional charcoal manufacture also known as briquets is also made from scrap wood, sawdust and wood chip product. It is known that some manufacturers include a percentage of softwood but for the most part, the product is derived from hardwood. Briquets do have binders added and there are some types that have accelerants added to make them extremely quick to lite. Personally, I can detect those additives and feel they do change the overall flavor when cooking foods over them but you can make that determination for yourself.

Controlled flavor only comes from wood and the best and safest flavors, from hardwood. Charcoal is a fuel, it is for heat, and the only flavor it produces is when meat/poultry drippings fall directly on the hot coals and vaporize, stimulating flavors. Never are flavors stimulated from the briquet or charcoal.

So, Who Is The Ingredient?

If the definition of an ingredient is a substance that contributes or makes up a mixture, then truly hardwood, regardless if it cooking wood form is in chips, chunks, logs, dust or charwood, is an ingredient in wood-fired cooking recipes as it gives off its distinct organic flavor compounds that make up the cell structures. Heat is NOT an ingredient and that is what charcoal is: HEAT! A claim to be an ingredient just holds no truth.

Did you find this post informative? Leave a comment or suggestion as we’d love to hear from you so we can bring the information you’re looking for. And don’t forget, follow us and subscribe so you don’t miss a thing!

Other related reading:

related reading on our blog for smoking with wood.

HOW TO TURN YOUR CHARCOAL GRILL INTO A SMOKER

HOW TO USE CHARCOAL WITH WOOD IN COOKING

HOW MUCH WOOD TO ADD WHEN SMOKING

Products discussed in this Blog:

Wood Chips- Grande Sapore®

Wood Chunks- Single & Double Filet

Charwood

Dr. Smoke Charcoal needs to be supplemented by Smokinlicious wood products!

Our gorgeous filet of salmon is awaiting Chef Calle to turn it into Charwood Grilled Salmon on a kettle grill using a two-zone method along with Smokinlicious® wood chips!

Charwood Grilled Salmon Fillets for a Hint of Smoky Flavor

By: Chef Calle, Resident Executive Chef

Chef Calle here and thanks to SmokinLicious®, I’m going to offer an easy and palate-pleasing method to cook and lightly smoke fresh salmon fillets over a Charwood fire that features a small number of smoking chips. With this approach, the smoking chips infuse a delicate smoky flavor to the salmon without overpowering its delicious fresh taste.

Today, I’m using a Stok® Tourist™ grill, clearly one of the best Charwood grilling and smoking units on the market. If you don’t have a Stok®, just about any Charwood grill will work, if its heat chamber has room enough for both the Charwood and wood chips.

Charwood Grilled Salmon- Preparation

Preparation is key with salmon and setting up the cooking equipment. So, first prepare the fresh salmon fillets by lightly seasoning with EVOO, salt, pepper and if you have it- fresh dill or fennel. Let them sit and soak up all those great flavorful ingredients for about half an hour or until the salmon reaches room temperature.
Chef’s Tip: Do not use salmon that is past its prime, thinking that the smoke will disguise the slightly off flavor of the fish. Only use the best salmon available.

While the fish is marinating, begin preparations for the actual grilling by first firing up SmokinLicious® all natural Charwood using a hollowed chimney starter. Never use charcoal lighter fluid! Or Charwood, charcoal briquettes, pretreated with petroleum-based starting fluid. In addition to ruining your salmon with a foul aftertaste, it’s safer not to consume the residue or remnants from petrochemical fire starter liquids.

After your embers have taken on a medium to high heat condition (grayish color), place them directly in the center of the grill’s heating chamber. Put the grill grate on over the fired embers and clean it by using either a halved onion or lemon like you would use a sponge but, do it quickly and in short strokes to avoid getting fingers or hands burned.

Smoking the Charwood Grilled Salmon

Next, position small amounts of the smoking chips (a few large handfuls, I’m using SmokinLicious® Grande Sapore) around the outer fringes of the main concentration of burning Charwood. This allows the wood chips to take on two roles- 1) indirectly contributing to the cooking process, and; 2) producing a burst of smoky vapor that flavors the fillets.

A minute or two after you’ve positioned the smoking wood chips and reattached the grate, place the salmon fillets, skin side down on the grate, directly over the medium embers and cover. Grill and smoke the salmon for about 4 to 6 minutes, uncover and gently turn the fillets over, cover and grill and smoke the skinless side for no longer than 2 to 4 minutes depending on the thickness of the fillets.

Chef’s Tip: Be careful not to overcook. You can gauge the finish of the fillets be being able to flake them with a fork.

When done, remove the skin by gently peeling away with a fork or just serve skin side down. For a nice finishing touch, brush with a bit more, high-quality EVOO, season with freshly ground salt and pepper to taste. Feel free to garnish with fresh dill, fennel edible flowers or lemon. Hope you enjoyed Chef Calle’s recipe Charwood Grilled Salmon Fillets for a Hint of Smoky Flavor!

Bon Appetit

Purchase products:

Charwood

Wood Chips- Grande Sapore®

More Related reading on “What Wood for Smoking” and other great smoking and grilling tips and techniques

Related reading:

-Charcoal Grilled Asparagus using Charwood

-WHY CHAR-WOOD IS THE BETTER OPTION OVER CHARCOAL

-THE ULTIMATE WOOD-FIRED CLAMS CASINO

-SNAPPER GETS WRAPPED IN CORN HUSK & COAL FIRED

Awesome technique by Chef Calle- so you can do-Charwood Grilled Salmon Fillets for a Hint of Smoky Flavor

Crushed or Diced wood chips

CRUSHED OR DICED WOOD CHIPS? Share on X

You see the options all the time. Crushed or diced tomatoes? Every chef knows when and why you choose one over the other. Did you know the same concept is true for wood chips?

At SmokinLicious®, the only true cooking wood Company, we produce our wood chips in the same manner as tomato processors! We crush the wood for our Grande Sapore® chips – these pieces produce a unique flavor because of their shape just like crushed tomatoes give a deeper flavor to recipes! These chips are meant to last and work with other ingredients for full flavor balance. We also offer our “diced” option of predetermined wood slices to produce our Minuto® and Piccolo® chips for smoldering on heat plates, cast iron, and flavor bars. Just as diced tomatoes give a fresh-from-the-garden taste, diced wood chips likewise produce a different, often more intense fresh wood flavoring.

SmokinLicious® only manufacturers cooking woods. That is our primary and only business. We know hardwoods for cooking, all types of wood-fired methods. And we know wood flavoring – how to get the best clean flavors from the select hardwoods ideal for cooking!

See for yourself why we are a superior product with a superior outcome. Enjoy the benefits of the knowledge of our flavorists and get the options you are looking for. Made the SmokinLicious® way!

Dr. Smoke- there is a smoking difference between crushed or diced wood chips

Our Culinary Team wants you know…

… that the crushing and dicing method of our making of culinary wood chips is strikingly similar in concept to how grapes are processed in the phases of wine making? For example, the Ripasso method of Italian wine production starts out with crushed, partially dried grapes and proceeds on to fermentation with the leftover skins. Both Ripasso produced wine and our crushed or diced wood chips offer distinctive flavor, body and personality in a class of their own!

We have selected some of our Quora Grilling & Smoking Questions/Answers for you!

Gilling & Smoking Questions/Answers Share on X

Grilling & Smoking Questions— We’ve all heard the saying, “There are no stupid questions”. I answer a lot of questions about cooking, grilling, smoking, and wood-fired cooking over the course of a week. I am always surprised that when writing on these topics, I don’t often think of the truly novice cook and offer very basic tips. So, today, that’s what my goal is.

Grilling & Smoking Questions: When cooking a rack of ribs, do you cut them into individual pieces and then grill or leave them on the rack?

I honestly understand where this question comes from. You often see ribs served pre-cut into single bone servings at restaurants so why wouldn’t you start to think they must be cooked that way.

Unfortunately, the best way to cook ribs is as a rack when purchasing baby back or St. Louis cut spare rib for pork or beef ribs. This allows a crust to form on the outside when cooked, and for the rub to penetrate the entire rack so the flavors are more even.

Grilling & Smoking Questions : What is the white stuff on the bottom of the pork ribs?

That is a membrane we call silver skin that generally is left on the rack when the butcher cuts the meat. You always want to remove that membrane as it can prevent the meat from tenderizing and is rubbery if eaten. Simply take a butter knife and insert between the membrane and the meat at one end. Loosen it and then gripping the membrane with a paper towel, peel it off, trying to get it in one piece.

Grilling & Smoking Questions: How do I cook chicken on the grill so it doesn’t dry out?

For those that don’t feel like a master of the grill, just doing meats on the grill can pose a challenge. Chicken is no exception. In fact, it can be a difficult protein to grill since white and dark meat cook at different rates. The easiest method of ensuring moist and flavorful chicken, is to cook it on a two-zone grill set up. That means only half the burners are turned on while the chicken is placed on the grate that has no burners on. This allows the heat to radiate to the chicken and cook without burning the skin or cooking beyond 165°F.

Grilling & Smoking Questions : Do I soak my wood chips or chunks to make smoke?

Great question and one to ask before you start. No, do not soak the chips or chunks or any wood product for that matter unless a manufacturer of specific equipment requests it to be soaked. When you soak the wood, only the outer layer, about 1/8-inch thick gets wet. Once a wet wood is applied to a hot fire, the fire’s energy works to remove the excess water in the form of steam. This take energy from the fire which means you can alter the cooking temperature of the equipment. Apply wood product dry to get the best flavor from the wood even if using a smoker box or aluminum foil.

Grilling & Smoking Questions : What differentiates charred food from burnt food?

Let’s first define what charred foods are. When you char a food which usually is an animal protein or thick-skinned vegetable but can be just about anything, a dark colored outer crust forms either around the edges of the food item or completely across the food’s surface. The inside of the food will retain moisture and tender texture. If the food item is dry, tough, and an ugly color, it’s burnt.

Grilling & Smoking Questions: Does soaking your steak in marinade overnight make it juicier?

Marinades are ideal when you want to add a flavor level to meats, poultry and fish. The thing with marinades is you need to be careful not over-marinate. Since meat is 75% water, adding another liquid i.e. marinade, will not penetrate beyond the outside. Oh, you can cut some slits into the meat, fish, or poultry to get is a bit deeper but marinating something overnight will not get any more flavor into the food item. Plus, you take the risk of producing a mushy result if the protein of the meat is broken down too far.

Grilling & Smoking Questions : I assume when you smoke with wood it takes quite a bit of wood to make the smoke. Exactly how much do I need?

This is one misunderstanding that drives me crazy! It is not about the quantity of wood for hot smoking. Quality and moisture are the keys. First, find a hardwood and only hardwood, that has some moisture to it. About 25% is ideal. Whether you’re using a gas grill, charcoal grill, or electric unit, you’ll only need about 6-8 ounces of hardwood to start. Know up front, you won’t and shouldn’t see a ton of smoke and that smoke should be light in color.

Grilling & Smoking Questions : How do a get “fall off the bone” ribs when I grill?

I’m going to be completely honest – you don’t want fall off the bone ribs! If you prepare the ribs correctly – trimming the excess fat, removing the silver skin, and marinating with your favorite rub, brine or marinade – grill and/or smoke them at a lower temperature (I prefer 225°F) for roughly 3 hours, and then check for doneness with the “bend test”. Taking a pair of tongs, lift the ribs in the center of the rack from the grate. If they bend and have slight cracking to the meat, they are done. You’ll still find the meat will come right off the bone when you bite into it.

Grilling & Smoking Questions : What should you do first before using a new grill or smoker?

Clean it then test burn it without food. You need to clean the surfaces – inside lid, grates, side walls – to remove any remaining chemicals from the grill’s construction. To extend the life of the grill grates, season them with a high heat oil such as avocado, peanut, or canola oil. Simply brush or wipe on the oil with a small, clean paint brush or with a paper towel. Wipe off the excess and then follow with a test burn.

By running a test burn, you can remove any further impurities left from the manufacturing of the unit so you have no tainted flavors to your foods. If you’ve purchased an LP/Gas unit, test for leaks before lighting the grill. Oh, and always read the manual first thing so you know full operation and warnings on your unit.

I’ll be sure to provide follow up posting on questions that come my way in the future to ensure that I’m always assisting everyone – from novice to pro cook.

Making you an informed consumer through valuable articles like this one. Leave us a comment and follow us or subscribe for more great recipes, techniques, tips, and the science behind the flavor. That’s SmokinLicious®.

SmokinLicious® products:

Wood Chunks- Double & Single Filet

Wood Chips- Grande Sapore®, Minuto® & Piccolo®

Other common questions

-HOW MUCH WOOD TO ADD WHEN SMOKING

-3 METHODS OF SMOKING BOSTON BUTT FOR AUTHENTIC BARBECUE FLAVOR

-WHAT WOOD TO USE FOR SMOKING: A PRIMER

These are the small bags of wood chips for the technique BBQ Grill & Smoker pan, try the 3 pack or a box!

Welcome QVC shoppers who purchased the Technique Pre-seasoned Cast Iron 11″ BBQ Grill Pan & Smoker over the U. S. holiday weekend (July 4th). Dr Smoke did some research and watched the demonstration of this product by the great people of QVC. During the segment that I watched they recommended the use of Smokin’ Dust® with this unit. While this is true, I would also recommend the use of Smokinlicious Wood Chips as well! We have tested other stove top smokers and found that with the heavier “cast” iron pans our Wood Chips sometimes perform better than our Smokin’ Dust®

When applying our Smokinlicious Smokin’ Dust® with the Technique Pre-seasoned Cast Iron 11” BBQ Grill Pan & Smoker you may have to add water to make a paste and put it on the bottom tray of the unit. This will prolong the burn life of the Smokin’ Dust® and increase the smoke flavor during the cooking process

We have ordered a unit and will be testing our products in the next couple of weeks. Dr Smoke and the culinary crew will be testing this unit and will be adding information to our “Match your Cooker“ section of our web site. Please check back to Smokinlicious®for updates! Please enjoy your unit!

If you need additional assistance, regarding product compatibility, or tips on smoking,please call 1-800-941-5054

Bon Bar B Q!

Dr. Smoke-create smoked foods with our wood chips for the Technique BBQ Grill & Smoker

Our finished Smoked Rhubarb

Try Rhubarb (smoked) for a less tart taste! Share on X

Rhubarb Smoked – I will make a confession: I don’t like rhubarb, a spring to early summer perennial vegetable, on its own, likely due to the very tart flavor. I do, however, enjoy this vegetable smoked and then blended with a sweet fruit.

This is likely why you may not have realized that rhubarb is a perennial vegetable since this is so widely used for dessert items. The rhubarb stalks are suitable to eat but the leaves are poisonous meaning they should never be eaten or added to a smoothie. Since this is a tart vegetable, I am going to first smoke it to change the balance of that tartness. Later, I plan to use these smoked stalks in combination with some smoked strawberry to make a strawberry-rhubarb fool, a delicious treat or dessert.

For now, let’s get about a pound of fresh rhubarb, hopefully from a garden or a fresh market, and meet at the smoker for an easy method of infusing wood flavoring to this tart stalk vegetable.

Smoked Rhubarb- Selecting and Preparing

Rhubarb is a perennial vegetable that prefers cold conditions to thrive. When first planted, you won’t be able to harvest any of the stalks until the second year, similar to growing asparagus. When ready to harvest, you’re looking for stalks 12 to 18-inches in length with good girth to them. If the stalks are too thin, that means the plant does not have enough nutrients.

Here is a great guide on growing your own rhubarb for those that want to add to your garden production or simply like this vegetable: https://happydiyhome.com/growing-rhubarb/

Once harvested, clean well under water and pat dry. Trim all the leave ends from the stalks as these are poisonous, and discard. Note you can compost the leaves as the poisonous oxalic acid breaks down quickly when decomposition begins.

I prefer to cut my stalks into 3-4-inch lengths. That’s it! Likely one of the easiest vegetables to prepare for the smoker. Speaking of the smoker, time to prepare ours. I’ll be using an electric smoker today since smoking rhubarb takes very little time.

Tasting Notes: Whether to cut the stalks is dependent on what you plan to do with the rhubarb so adjust this step according to your planned recipe.

Smoked Rhubarb- Fire Up the Smoker!

I’ll be using a standard vertical electric smoker that uses lava rocks as the radiator of the heat as well as an electric element as the fuel/heat source. My electric smoker allows me to use wood chunks so I have an assortment of small sizes that total about 6 ounces of hardwood. The double filet wood chunk size is ideal and as a tip, if you note to SmokinLicious® the need for thin chunks, these can be provided.

My set up is simple: I wrap one of my grill grates in aluminum foil, place my element on the lava rocks and insert wood chunks between the element’s spaces. I’m using a combination of maple and cherry hardwood. I add my water pan with about 2-inches of hot water so energy from the unit isn’t wasted heating up the water. On goes my tray of pre-cut rhubarb that are spaced to allow the smoke to penetrate all around. Leave these untouched on the smoker for about 20-25 minutes or until the thickest stalks are fork tender.

The best part about rhubarb on the smoker is it takes very little effort. Trim, clean, and cut to size then place on the grate and smoke. In about 15 minutes time, you’ll see a golden hue come out of the rhubarb pieces. That means the smoke has penetrated its great flavor. Using a fork or the tip of a paring knife, I check the thickest stalk to be sure I can easily pass the metal tip thru. If so, then the rhubarb is tender and ready to come off the smoker.

If your plans are to prepare this for rhubarb pie, then just continue with your favorite recipe. This step is simply to provide another flavor level and begin the cooking process. Check in with us soon as we release our version of the strawberry-rhubarb fool featuring this smoked rhubarb and smoked strawberry.

What’s your favorite method of cooking rhubarb? Leave us a comment to opine and subscribe to get all our postings on tips, techniques and recipes. Bringing innovation to wood fired cooking with recipes, techniques and the science behind the fire, smoke, and flavor. That’s SmokinLicious®.

SmokinLicious® products used for this technique:

Wood Chunks- Double Filet

Additional reading:

-ELECTRIC SMOKERS: WHEN IS A WOOD CHIP DEAD?

-EASY GRILL ROASTED TOMATOES

-ODE TO THE GRILLED FAVA BEAN

Dr. Smoke- Take tart to the smokey side with fresh, smoked rhubarb!